HomeAbout usProducts  Contact


RMC-1000F
Material Safety Data Sheet

Composition / Ingredient Information

Material  CASNumber %
Polymers 40-60
*Vinyl Acetate Monomer. 108-05-4 <1
Kerosene 8008-20-6 <2
Blend of Substituted Aromatic Hydrocarbons 40-60

*Disclosure as a toxic chemical is required under Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR part 372.

First Aid Measures

Inhalation
If inhaled, remove to fresh air.  If not breathing, give artificial respiration.  If breathing is difficult, give oxygen.  Call a physician.

Skin Contact
Flush skin with water after contact.  Wash contaminated clothing before reuse.

Eye Contact
In case of contact immediately, flush eyes with plenty of water for at least 15 minutes.  Call a physician.

Ingestion
If swallowed, do not induce vomiting.  Allow victim to rinse his mouth and then to drink 2-4 cupfuls of water.  Never give anything by mouth to an unconscious person.  Call a physician.

Notes to Physicians
Activated charcoal mixture may be administered.  To prepare activated charcoal mixture, suspend 50 grams activated charcoal in 400-ml water and mix thoroughly.  Administer 5 ml/kg or 350 ml for an average adult.

Because of the danger of aspiration, emesis or gastric lavage should not be employed unless the risk is justified by the presence of additional toxic substances.  Activated charcoal may induce vomiting, but may be given after emesis or lavage to absorb toxic additives.  Steroid therapy in mild to moderate cases does not improve outcome.  Bacterial pneumonia often occurs after exposure, but prophylactic antibiotics are not indicated and should be reserved for documented bacterial pneumonia.

Physical and Chemical Properties

Physical Data
     
Appearance................ Amber
    Form.......................... Liquid
    Odor...........................Aromatic
    Specific Gravity.......... 0.969 @ 60/60F (16/16C)
    Density.................... 8.07 lbs./gal. @ 60F (16C)
    Solubility in water....... nil

Stability and Reactivity

Chemical Stability
Stable at normal temperatures and storage conditions.

Incompatibility
Incompatible with strong oxidizers.

Decomposition
Decomposes with heat.  Hazardous decomposition products include oxides of carbon.

Polymerization
Will not occur.

Toxicological Information

Animal Data

Kerosene:
Inhalation 4 Hr. LC50: >5,000 mg/m3 in rats
Skin Absorption LD50: >2,000 mg/kg in rabbits
Oral LD50: >12,700 mg/kg in guinea pigs
Vinyl Acetate Monomer:
Inhalation 4 hour LC50 4,000 ppm in rats
Skin Absorption LD50 2,335 mg/kg in rabbits
Oral LD50 2,920 mg/kg in rats

A single ingestion exposure to Kerosene produces intestinal irritation (anal lesions).  Repeated exposure to Kerosene produces intestinal irritation, diarrhea, and inactivity.

Mouse skin painting studies indicate that petroleum middle distillates which include kerosene can cause skin cancer.  Kerosene does not produce developmental toxicity and heritable genetic damage in animals, or genetic damage in mammalian cell cultures.  Genetic damage has been observed in bacterial cell cultures.          

Vinyl Acetate is a slight skin and a severe eye irritant, but is untested for animal sensitization.  No effects from repeated exposure to Vinyl Acetate by inhalation were observed at 100 ppm in rats.  Exposure to higher concentrations of Vinyl Acetate by inhalation caused eye irritation and lacrimation, reduced weight gain, and irritation of the respiratory tract with breathing difficulty.  The effects observed in rats and mice exposed by inhalation to 200 and 600 ppm for two years include reduced body weight.  Repeated exposures by administration of Vinyl Acetate in the drinking water caused decreased weight gain, and low liver weights. Reduced body weight occurred in rats administered 5000 ppm in their drinking water for two years.  Vinyl acetate is weakly carcinogenic in rats, but not in mice.  The compound does not have an adverse effect on the development of rats and its effect on reproduction is not considered significant.  The genotoxicity of vinyl acetate is equivocal.  Genetic damage was produced in some types of cell cultures and in animals, but was negative in other studies.  No tests for heritable genetic damage were available.

Ecological Information

Kerosene:                                         
Low toxicity with a 24 hour TLm in bluegill sunfish: 2,990 mg/L

Disposal Considerations

Waste Disposal
Treatment, storage, transportation, and disposal must be in accordance with applicable Federal, State/Provincial and Local regulations.

US Federal Regulations

TSCA Inventory Status........... Reported / Included

Title III Hazard Classifications Sections 311, 312
           Acute.............................................. Yes
         Chronic............................................ Yes
         Fire.................................................. No
         Reactivity.......................................... No
         Pressure............................................ No

Other Information

npca-hmis Rating
          
Health.................. 2* (Chronic Health Effects)
         Flammability........... 1
         Reactivity.............. 0

Personal Protection rating to be supplied by user depending on use conditions


Hazardous Identification

Potential Health Effects

Minute amounts of petroleum hydrocarbons aspirated into the lungs during ingestion or vomiting may cause mild to severe pulmonary injury and possible death.

Individuals with preexisting diseases of the kidneys or liver may have increased susceptibility to the toxicity of excessive exposures.

Inhalation of fumes or vapors from heated product may cause skin, eye and respiratory tract irritation.

Inhalation of Kerosene may cause nonspecific discomfort, such as nausea, headache, or weakness; temporary nervous system depression with anaesthetic effects such as dizziness, headache, confusion, incoordination, and loss of consciousness; or possibly modest initial symptoms of lung irritation, followed in hours by severe shortness of breath, requiring prompt medical attention.

Ingestion of Kerosene may cause liver and kidney effects; or gastrointestinal irritation with upper abdominal pain, heart burn, nausea, vomiting, and diarrhea.  However, there may be no symptoms at all.  A serious ingestion hazard is aspiration (liquid entering the lungs during ingestion or vomiting) which may result in chemical pneumonia.  Symptoms include coughing, gasping, choking, shortness of breath,

bluish discoloration of the sin, rapid breathing and heart rate and fever.  Pulmonary edema or bleeding, drowsiness, confusion, coma and seizures may occur in more serious cases.  Symptoms may develop immediately or as late as 24 hours after the exposure, depending on how much chemical entered the lungs. 

Pulmonary fibrosis has been reported in cable plant workers exposed to mist and vapors of mineral oils and kerosene for 5-35 years.  Because of mixed exposures to mineral oils as well as kerosene it is difficult to attribute these effects to kerosene alone.

Carcinogenicity Information
Vinyl Acetate Monomer has been classified by the Internal Agency for Research on Cancer (IARC) as possibly carcinogenic to humans (Group 2B).  This IARC classification was based upon limited evidence of carcinogenicity to animals and inadequate evidence of carcinogenicity to humans.

Fire Fighting Measures

Flammable Properties
           
Flash Point................. >230F (>110C)
          Method....................... PMCC

Extinguishing Media
          
Water Spray, Foam, Dry Chemical, CO2.

Fire Fighting Instructions
       
Wear self-contained breathing apparatus. 
      Wear full protective equipment.

Accidental Release Measures

Note: Review fire fighting measures and handling (PERSONNEL) Sections before proceeding with clean up.  Use appropriate PERSONAL PROTECTIVE EQUIPMENT during clean up.  Soak up with sawdust, sand, oil dry or other absorbent material.  Remove source of heat, sparks, flame, impact, friction, or electricity.  Dike spill.  Prevent material from entering sewers, waterways, or low areas.

Spill Clean-Up
Soak up with sawdust, sand, oil dry or other absorbent material.

Accidental Release Measures

Spills are very slippery and should be cleaned up promptly.

Handling and Storage

Handling (Personnel)

Avoid breathing vapors or mist.  Avoid contact with eyes, skin, or clothing. Wash thoroughly after handling. 

Handling (Physical Aspects)

Keep away from heat, sparks and flames.

Storage

Store in a well-ventilated place. Keep container tightly closed.  Store in accordance with National Fire Protection Association recommendations.

Exposure Controls

Engineering Controls
Use only with adequate ventilation.  Keep container tightly closed.

Personal Protective Equipment

Eye/Face Protection
Wear coverall chemical splash goggles or safety glasses.
Respirators
Where there is potential for airborne exposures in excess of applicable limits, wear
NIOSH/MSHA approved respiratory protection.
Protective Clothing
Where there is potential for skin contact have available and wear as appropriate
Impervious gloves, apron, pants, hood and jacket.

Exposure Limits

Vinyl Acetate Monomer:
PEL(OSHA) None established
TLV (ACGIH) 10 ppm, 35 mg/m3, 8 hr, TWA, A3
STEL 15 ppm, 53 mg/m3, A3
AEL* (RMC) 10 ppm, 8 & 12 hr, TWA
Kerosene:
PEL(OSHA) None established
REL(NIOSH) 100 mg/m3, 10 hr TWA
TLV (ACGIH) as total hydrocarbon vapor:
200mg/m3, 8 hr TWA, Skin; A3
AEL* (RMC) None established

The skin notation following the exposure guideline refers to the potential for dermal absorption of the material.  It is intended to alert the reader that inhalation may not be the only route of exposure and that measures to minimize dermal exposure should be considered

* ael is RMCs acceptable exposure limit.  Where governmentally imposed occupational exposure limits which are lower than the AEL are in effect, such limits shall take precedence.

Shipping Information

DOT
          
Proper Shipping Name................ Not Regulated

IMO
          
Proper Shipping Name................ Not Regulated

Shipping Containers
          
Steel Drums UN1A1/Y/100

The data in this Material Safety Data Sheet relates only to the specific material designated herein and does not relate to use in combination with any other material or in any process.

__________________________________________
Home
| Profile | Our Products | Contact Us
© 2014 RMC Energy Group., LLC. All Rights Reserved.